6R1TI30Y-080原装进口
热处理调质线，现场生产工艺流程，所要采集温度点的位置如下图：
3.2、PLC温度数据采集程序的编制
DVP04PT温度测量模块可接受外部4点铂金属温度传感器(PT1003线100Ω)，将其转换成14位的数字信号。通过DVP-PLC主机程序以指令 FROM/TO来读写模块内的数据，模块内具有49个CR(ControlledRegister)寄存器，每个寄存器有16Bits。电源单元与模块分离，体积小，安装容易。可选择摄氏温度(℃)或华氏(℉)温度，摄氏温度输入分辨率为0.1℃，华氏温度输入分辨率为0.18℉。
两块温度测量模块扩展于PLC主机的右侧，
6支三线制PT100温度传感器按规定接入2块DVP04PT温度测量模块中，**块接入4支，接入4个通道，第二块接入2支，使用1、2两个通道，不用的通道，短接避免干扰。依据台达PLC特殊扩展模块的规则：主机DVP32EH右侧**个特殊扩展模块所在的位置编号为K0,右侧第二个特殊扩展模块所在的位置编号为K1,依此类推，最多扩展八块……
编写温度采集的数据程序如下：
程序说明：
**块测温模块
（1）利用FROM指令读取模块DVP04PT-H2内＃0寄存器（CR）内的机种编码=H6402，以便检测判断模块是否存在，种类是否正确。
（2）利用TO指令，在PLC由STOP→RUN的**个扫描周期内，设定CH1~C4输入信号的取样平均次数为4次。
（3）判断DVP04PT-H2是否正确，正确事时导通，从CR#6~CR#9中读取CH1~CH4测量摄氏温度(°C)信号平均值共4笔放在 D100~D103中。从CR#18~CR#21中读取CH1~CH4测量摄氏温度(°C)信号现在值共4笔放在D110~D113中。
3.3、温度数据显示、记录组态程序的编制
组态监控软件采用北京亚控公司的组态王6.53版本，由于本项目是试验性的采集、记录数据，故采用64点演示版，开发与运行，间断地运行两个小时足以。
3.3.1组态王与台达PLC通讯的建立
台达的DVP系列PLC和上位机的组态王通讯采用串行通讯，使用组态王本身驱动，支持RS232和RS485两种通讯方式。
本例采用RS485通讯，硬件配置设置值如下：
计算机通过RS232串口接转换模块，变成RS485信号后，接到PLC的485口上
波特率9600
数据位7位
停止位1位
校验位偶校验
切记：将PLC中决定通讯格式的特殊数据寄存器D1120设置为：0X8E
3.3.2组态数据显示画面、温度记录曲线
用组态王软件可以实现精确、细腻的互动显示操作，大量的图库精灵，多种通讯驱动程序，强大的在线、离线模拟功能，支持配方功能和多种控件，能完成各种物理量如温度、压力等的实时曲线、历史曲线的数据存储，具有打印功能，可满足各种工艺要求。温度显示画面、历史曲线显示画面如下：
四、结束语
组织有关技术人员，对测量的历史数据曲线进行分析，很快得出结论，提出整改方案，整改后效果明显，产品合格率大幅度提高。本温度数据采集系统为整改方案制订提供了关键性的依据。

*全新原装正品，现货直供！所有备件的质保期均为1年，经过专业测试认证。订购咨询热线：18105962758
*如果您需要订购产品超过1件，请与我们联系，我们可以为您提供折扣。
*我们仅采用快递方式递送备件。（顺丰）
*如果您发现其他供货商为相同产品提供更为低廉的价格，我们也愿意参照其价格向您提供进一步的折扣。如果还有其他任何问题，请随时与我们联系。
*请让我们知道您有任何，备品，备件的需要，我们可以给您进一步的援助，我们等候您的咨询。

诚信经营，质量为首，诚信至上，鼎晟达竭诚为您服务
***************漳州鼎晟达自动化设备有限公司***************
联系人：林朝艺（销售经理）
手机 ：18105962758
QQ ：2880842795
邮箱 ：2880842795@qq.com
传真 ：0596-3119658（请备注林工收）

【主营产品】
1：Invensys Foxboro（福克斯波罗）：I/A Series系统，FBM（现场输入/输出模块）顺序控制、梯形逻辑控制、事故追忆处理、数模转换、输入/输出信号处理、数据通信及处理等。

2：Invensys Triconex: 冗余容错控制系统、基于三重模件冗余（TMR）结构的最现代化的容错控制器。

3：Westinghouse（西屋）： OVATION系统、WDPF系统、WEStation系统备件。

4：Rockwell Allen-Bradley: Reliance瑞恩、SLC500/1747/1746、MicroLogix/1761/1763/1762/1766/1764、
CompactLogix/1769/1768、Logix5000/1756/1789/1794/1760/1788、PLC-5/1771/1785等。

5：Schneider Modicon（施耐德莫迪康）：Quantum 140系列处理器、控制卡、电源模块等。

6：ABB：工业机器人备件DSQC系列、Bailey INFI 90等。

7：Siemens(西门子)：Siemens MOORE， Siemens Simatic C1，Siemens数控系统等。

8：Motorola（摩托罗拉）：MVME 162、MVME 167、MVME1772、MVME177等系列。

9：XYCOM：I/O 、VME板和处理器等。

10：GE FANUC(GE发那科)：模块、卡件、驱动器等各类备件。

11：Yaskawa（安川）：伺服控制器、伺服马达、伺服驱动器。

12：Bosch Rexroth（博世力士乐）：Indramat，I/O模块,PLC控制器,驱动模块等。

13：Woodward（伍德沃德）：SPC阀位控制器、PEAK150数字控制器。

14:工业机器人系统备件。

15： 英维斯(TRICONEX):TRICON DCS的系列，如：3805E

另外还有 雅马哈(YAMAHA), 贝加莱(B&R)， 欧姆龙(OMRON), KEBA， 安川(YASKAWA) 等品牌的停产备件。

-----------------------------------------------------------------------------
ROSEMOUNT TEMPERATURE TRANSMITTER 444TJ1U1A1NA 0-300 C

USED ROSEMOUNT SMART MAGNETIC FLOW TRANSMITTER 8712CR12

Rosemount 1144 Pressure Transmitter w/Display NR

Rosemount 8705 TSA Teflon Lined Magnetic Flow Tube S32

Rosemount 444R-1u1D2NA temperature transmitter

ROSEMOUNT 3051C STAINLESS STEEL PRESSURE TRANSMITTER

Rosemount 268 HART Remote Transmitter Interface S42

2" 150# Rosemount 8701-TSA020S1 Magnetic Flowtube S31

ROSEMOUNT TRANSMITTER 1151DP3E12B2 *NICE*

ROSEMOUNT TRANSMITTER 1151DP3E12B1 2000PSI 2000 PSI

Rosemount 3095 Smart Modbus Transmitter

ROSEMOUNT 444RL2U2A2E5 TEMPERATURE TRANSMITTER 444

Rosemount Alphaline Pressure Transmitter 0444RL3U1A1NA

Rosemount 8732C Smart Transmitter 8732CT12N0M4 1.5-2"

Rosemount 1144 Pressure Transmitter NR

Rosemount Vortex 8800 CW04 Smart Hart Flow Transmit S32

Rosemount Vortex 8800 Flow Transmitter NEW S35

Rosemount 1151AP/1151GP Pressure Transmitter

ROSEMOUNT MODEL 444 ALPHALINE TEMPERATURE TRANSMITTER

ROSEMOUNT TRANSMITTER 1DP3E12B2

ROSEMOUNT 3051TG3A2B22AA0?078K5

ROSEMOUNT ALPHALINE TEMPERATURE TRANSMITTER NEW NIB

ROSEMOUNT TRANSMITTER 1151DP3E12

ROSEMOUNT 1151 GP PRESSURE TRANSMITTER

Rosemount Alphaline Temperature Trans. 444RL #7 S31

NEW ROSEMOUNT 1151DP6S22B1 PRESSURE TRANSMITTER

ROSEMOUNT MICRO MOTION 2700 R 13ABUEZZZ TRANSMITTER

ROSEMOUNT ALPHALINE TEMPERATURE TRANSMITTER USED

NEW ROSEMOUNT 3051CD1A22A1AB4?I5L4 PRESSURE TRANSMITTER

ROSEMOUNT ALPHALINE TEMPERATURE TRANSMITTER NEW NIB

ROSEMOUNT 2024 PRESSURE TRANSMITTER P TO I P/I

Rosemount 3051 S1CA2A2A11A2JKC?Q8 0-150 PSI Tranmitter

ROSEMOUNT 3051CG4A22A1A

Rosemount Vortex 8800 Hart Smart Family Transimitter

Rosemount Transmitter Mounting Bracket Kit 20Pcs

Rosemount 1151 Liquid Level Transmitter 1151LT6SG0Y22D

NEW ROSEMOUNT 1151GP9S2AP2 PRESSURE TRANSMITTER

ROSEMOUNT TRANSMITTER 1151DP3E12

ROSEMOUNT 3051CA1A22A1AA0?060B4L4 W/ 1199SCW11A11

Rosemount 1151 Liquid Transmitter 1151LT5EA0A12DM?1

Rosemount Alphaline Temperature Transmitter new

NEW ROSEMOUNT 1151GP7S2AP2 PRESSURE TRANSMITTER

Rosemount 1181C Uniloc 2-Wire Transmitter 1181-C New

Rosemount Vortex 8800A W020 Smart Hart Flow Transmt S32

ROSEMOUNT 1151DP3S52B1PRE?SSURE TRANSMITTER ***NNB***

ROSEMOUNT 244P HEAD MOUNT TEMPERATURE TRANSMITTER

ROSEMOUNT 3044CA1B4 *NEW*

Rosemount 3244MV-F1K504 Temp Transmitter 3244MVF1K504

Rosemount Transmitter 3095* 170PSIG 11-55VDC 4-20MA out

ROSEMOUNT 1151LL5B2A4CE

ROSEMOUNT 8712CR12M4 FLOW TRANSMITTER 115VAC

Rosemount 3095MA Multi Variable Mass Flow Transmitter

Rosemount 1151GP Pressure Transmitter w/ Remote Sensor

ROSEMOUNT 644R -10o TO150o C TEMPERATURE TRANSMITTER

ROSEMOUNT 444RL TEMPERATURE TRANSMITTER

2 Rosemount Alphaline Thermocouple Transmitter; *A5

ROSEMOUNT 3051CG4A22A1AS1?B414 W/ 1199RTW11A31A13

ROSEMOUNT 3051CG4A22A1AS1?B414 W/ 1199SCW11A11

ROSEMOUNT 444RL TEMPERATURE TRANSMITTER

115-1GP8F12B Rosemount Transmitter

Rosemount Alphaline Temperature Trans. 444RL S29

Rosemount 3051 CD1A02A1JS5K6C1?Q4Q8 0-25 IN H2O

ROSEMOUNT PRESSURE TRANSMITTER 3051-CG2A22A1AS?0E5M5QP

ROSEMOUNT TRANSMITTER FOR EXPLOSIVE ATMOSPHERE

NEW ROSEMOUNT TRANSMITTER 1151GP7E12S1B1 SEAL 1199RFW

ROSEMOUNT PRESSURE TRANSMITTER 3051CD4A52A1AB4?C6Q4DF

ROSEMOUNT TRANSMITTER 1151DP4S12S2B1 REMOTE FLG 686IN07

ROSEMOUNT 3051CA1A22A1AS1?E5 W/ 1199WNB05SSCW50?LA000

ROSEMOUNT DIETERICH STANDARD PNT10S007HADS0S?00003A1A

ROSEMOUNT PRESSURE TRANSMITTER 3051-CG3A22A1AS?0E5M5QP

ROSEMOUNT PRESSURE TRANSMITTER 3051-CG3A22A1AS?05M5E5QP

ROSEMOUNT 1151DP3E12

NEW ROSEMOUNT 3051 DIFFERENTIAL PRESSURE TRANSMITTER

NEW ROSEMOUNT 3051 GAGE PRESSURE TRANSMITTER

USED FOXBORO/ROSEMOU?NT TRANSMITTER 823DP-D3S1NM2-M

NEW ROSEMOUNT 444RL1U1D2E5 TEMPERATURE TRANSMITTER

Rosemount 3051 Protection Terminal Block Kit 14Pcs

Rosemount 248 Temp Transmitter C/W 68 Sensor&Thermowe?ll

ROSEMOUNT 3051 GAUGE PRESSURE TRANSMITTER 601IN4

Rosemount 1151 Smart Pressure Transmitter, 0-200#

NEW ROSEMOUNT 3051 PRESSURE TRANSMITTER 0 - 1000 IN H20

ROSEMOUNT 1151DP4E2292B4 PRESSURE TRANSMITTER

NEW Rosemount 03031-3023-0042 0303130230042

ROSEMOUNT 44RL3U1A2E5 NNB

ROSEMOUNT 8712H SMART FAMILY MAG. FLOWMETER TRANSMITTE

Rosemount 0183P13J2N00N04?5E5 Sensor 0183*6632742 New

Rosemount 0183P13J2N00N04?0E5 Sensor 0183*6740184 New

ROSEMOUNT MAGNETIC FLOWTUBE

ROSEMOUNT PRESSURE TRANSMITTER 3051

ROSEMOUNT 1151 PRESSURE TRANSMITTER 1151GP6E22M1B1 ALPH

NEW ROSEMOUNT TEMPERATURE TRANSMITTER 444TK3U1A2E5 ALPH

Rosemount Temperature Transmitter 444TK1U1B2NA

NEW ROSEMOUNT 1151DP3E22 PRESSURE TRANSMITTER

Rosemount Smart Family 8700 Magnetic Flow Transmitter

NEW Rosemount Temperature Probe Model 79 Conection Head

Rosemount 444RL1U1A1E5 Temperature Transmitter New

NEW ROSEMOUNT 2024D2A22A0I1B4 TRANSMITTER

NEW ROSEMOUNT 2024 D2A22A2I1B4 TRANSMITTER

ROSEMOUNT TANK SPUD 01199-0061-0001 *NEW*

New Rosemount Model 79 Field Connection Heads Pair NR

ROSEMOUNT TEMPERATURE PROBES

ROSEMOUNT Temp.Sensor CAMCO 1/2"T-304 79-325-2; *B8

Rosemount 644 Intrinsically Safe Temperature Transmitte

NEW ROSEMOUNT 444RL2U1A2NA TEMPERATURE TRANSMITTER 444R

ROSEMOUNT 1151DP SERIES PRESSURE TRANSMITTER

NEW ROSEMOUNT NUCLEAR PRESSURE TRANSMITTER 1153GD9PA

1/2" 150# FLG Rosemount 870 Magnetic Flow Tube #5 S33

Rosemount 751AM4NAR Field Signal LCD Meter Indicator

Rosemount/Dietr?ich Mass ProBar FlowMeter MBR+25S NIB

ROSEMOUNT ALPHALINE TEMPERATURE TRANSMITTER 0444RL2U1B1

NEW Rosemount 3051S 2" Pressure Transmitter 0-100 PSI G

Rosemount 3051 Pressure Transmitter CD2A52A1AK5B4 works

ROSEMOUNT SERIES 183 THERMOCOUPLE 78N11C30N060 (NEW)

Rosemount Transmitter 1151DR2F12M1B2 Big Lot Plus More

ROSEMOUNT DIGITAL TRANSMITTER FLOWTUBE 8732C-T12E5M4

ROSEMOUNT 1151DP4S12M2B1D?F PRESSURE TRANSMITTER NIB

ROSEMOUNT TRANSMITTER AND FLOWTUBE 8732C-T12E5M4

ROSEMOUNT MAGNETIC FLOW TRANSMITTER 8712C R12M4B6

ROSEMOUNT ANALYTICAL 1054A ANALYZER PH/ORP TRANSMITTER

Rosemount 316SS 305131124-0300 Manifold Valve

Rosemount Analytical 613560 Power Supply New

Rosemount Alphaline Temperature Transmitter

USED ROSEMOUNT ALPHALINE TRANSMITTER 444TT1D1A1NAQ4

ROSEMOUNT 150-03 CONDUCTOR SENSOR

ROSEMOUNT SERIES 183 THERMOCOUPLE 78N11C60N180

Rosemount 1151LT4SA0F22D Liquid Level Transmitter REMAN

Rosemount 3311DS1J1B2F2G1?G2E5 Pressure Transducer

NEW ROSEMOUNT 1144 PRESSURE TRANSMITTER 1144 G0200A22

ROSEMOUNT 1135FLB1B1E5 TRANSMITTER

150# FLG Rosemount 870 Magnetic Flow Tube #6 S33

ROSEMOUNT 08712-0401 TRANSFORMER MODULE NIB

ROSEMOUNT 0444R TEMPERATURE TRANSMITTER 0444RL1U1D1NA

NEW ROSEMOUNT 3244MVF1E5M5U1C?2Q4 TEMPERATURE TRANSMITTE

Rosemount 11177-02H 1117702H Pressure Transmitter

Rosemount 78N11N00N090E5 0078*636360 Sensor/Probe New

ROSEMOUNT SMART PRESSURE TRANSMITTER 2088A1S22C4Q4 NSFP

ROSEMOUNT ALPHALINE TEMPERATURE TRANSMITTER 0444L1U1A1E

ROSEMOUNT TRANSMITTER MAGNETIC FLOWTUBE 8711-088011148

NEW ROSEMOUNT MAGNETIC FLOW TRANSMITTER M/N 8732C

Rosemount Magnetic Flow Transmitter 8712CR036B

ROSEMOUNT EXPLOSION PROOF CONNECTION HEAD & SHAFT

ROSEMOUNT PRESSURE TRANSMITTER 1144 A0200A22 200 PSI

Rosemount Analytical Thermocompensat?or 524-19590

ROSEMOUNT 1151DR2F22 DRAFT RANGE TRANSMITTER, 316 SST

USED FOXBORO/ROSEMOU?NT TRANSMITTER IAP10-D20C1F-M1

USED FOXBORO/ROSEMOU?NT TRANSMITTER 867EF-9D1CSE 316 SS

Rosemount Aerospace Temperature Transducer 0175DR3

Rosemount 3051 Pressure Transmitter CG1A22A New, Box

ROSEMOUNT 444RL2U1A1NA TRANSMITTER

ROSEMOUNT 444RL2U1A1EA ALPHALINE TEMP TRANSMITTER

Rosemount 1054B Chlorine Analyzer/Transm?itter 1054BT-01

USED FOXBORO/ROSEMOU?NT TRANSMITTER 867DFHD1SSE

ROSEMOUNT 244E TEMPERATURE TRANSMITTER

NEW GOULD/ROSEMOUNT TRANSMITTER PD3200-100-18-2?2-36-XX

Rosemount C1151 Alphaline Transmitter

ROSEMOUNT ALPHALINE TRANSMITTER 115 1GPOE12MB

ROSEMOUNT 1151GP6S22B2 ALPHALINE PRESSURE TRANSMITTER

Rosemount Uniloc 1181C-06-10 Two Wire Transmitter New

ROSEMOUNT 0142-01-13-54 CONDUCTIVIY SENSOR, NIB

Rosemount Transmitter Connection, Style A 1151

ROSEMOUNT 0303110450022 PRESSURE MODULE FOR MODEL 3051

FOXBORO/ROSEMOU?NT TRANSMITTER 861AM-CD-ML

FOXBORO/ROSEMOU?NT TRANSMITTER IAP20-122D11F-T

Fisher Rosemount Alphaline stainless pres. transducer

Rosemount 68 Sensor C/W 316SS Flanged Thermowell

NEW ROSEMOUNT 3051S PRESSURE TRANSMITTER NEW IN BOX

CAMERON BARTON FCX ROSEMOUNT ELECTONIC TRANSMITTER

Rosemount 396P-02-10-55 PH/ORP Transmitter 396P021055

Rosemount 3051 Smart Pressure Transmitter

ROSEMOUNT MAGNETIC FLOWTUBE MODEL# 8711TSA010R1N0

Rosemount Analytical Conduct Sensor MDL #1410613; *A2

Rosemount Pressure Transmitter 2090 SMART PA1S22C1C6

Rosemount Transmitter Mounting Bracket

NIB BAILEY/ROSEMOUN?T TRANSMITTER DQIF221 2000 PSI

ROSEMOUNT 1151GP7E22S1M1B?1 PRESSURE TRANSMITTER 7640230

NIB ROSEMOUNT TEMPERATUR CONTROL BOARD 637056 864 865

ROSEMOUNT VORTEX FLOWMETER 2 INCH 8800-CF020SA1N1?D1E5M5

Rosemount Model 1181C Two Wire Transmitter "NIB"

Rosemount Smart Family Temperature Transmitter 3144P

ROSEMOUNT PRESSURE TRANSMITTER W/ FLANGE 1GP7E22S1B1C6

Rosemount Vortex 8800 Series Flow Transmitter / Sensor

NEW ROSEMOUNT SMART TEMPERATURE TRANSMITTER 3051

Rosemount 1151GPGE12M1 Alphaline Pressure Transmitter

NEW ROSEMOUNT, 2" SPACER KIT, SST, 08800-5711-0201

ROSEMOUNT 1151 SMART PRESSURE TRANSMITTER 1151GP 100PSI

ROSEMOUNT VORTEX FLOWMETER 3 INCH 8800-CF030SA1N1?DE5M5

Rosemount Pressure Transmitter 1151 Smart

1151 Rosemount Pressure Transmitter

Rosemount Magnetic Flow Transmitter Smart Family NEW

Rosemount Temp Transmitter # 1151DP3E22B3 S# 0225971

ROSEMOUNT PRESSURE TRANSMITTER 1151-GP7S 300PSI 42.3mA
51AP6E12B1

资讯来源：漳州鼎晟达自动化设备有限公司